Directions:

• Place 8 clean 250 ml mason jars on a rack in a boiling water canner. Cover jars with water and heat to a simmer (180°F/82°C). Set screw bands aside. Keep jars hot until ready to use.


• Preheating Bernardin® lids is not advised. The sealing compound used for our home canning lids performs better at room temperature than it does pre-heated in simmering water (180°F). Simply wash lids in hot, soapy water, dry, and set aside until needed. Preheating can lead to less vacuum being achieved during water bath canning, and to buckle failures during pressure canning.


• In a large, deep stainless steel saucepan, combine oranges, lemon zest and juice and water. Bring to a boil over high heat, stirring constantly. Reduce heat and boil gently, stirring occasionally, for 40 minutes. Add chili peppers, partially cover and boil gently, stirring occasionally, until fruit is very soft, about 30 minutes. Remove and discard chili peppers.


• Bring mixture to a boil over medium-high heat, stirring constantly. Maintaining boil, gradually stir in all the sugar. If desired, add 1/2 tsp (2 ml) butter or margarine to reduce foaming. Boil hard, stirring occasionally, until mixture reaches gel stage, about 15 minutes. Remove from heat and test gel. (Gel Plate Test: remove mixture from heat; pour a spoonful of cooked recipe on a cold plate and place in freezer for a few minutes. A gel has been achieved when the product does not run together when separated with a spoon.) If gel stage has been reached, skim off foam.


• Quickly ladle hot marmalade into a hot jar to within 1/4 inch (0.5 cm) of top of jar (headspace). Using nonmetallic utensil, remove air bubbles and adjust headspace, if required, by adding more marmalade. Wipe jar rim removing any food residue. Centre sealing disc on clean jar rim. Screw band down until resistance is met, then increase to fingertip tight. Return filled jar to rack in canner. Repeat for remaining marmalade.


• When canner is filled, ensure that all jars are covered by at least one inch (2.5 cm) of water. Cover canner and bring water to full rolling boil before starting to count processing time. At altitudes up to 1000 ft (305 m), process –boil filled jars – 10 minutes.*


• When processing time is complete, remove canner lid, wait 5 minutes, then remove jars without tilting and place them upright on a protected work surface. Cool upright, undisturbed 24 hours; DO NOT RETIGHTEN screw bands.


• After cooling check jar seals. Sealed discs curve downward and do not move when pressed. Remove screw bands; wipe and dry bands and jars. Store screw bands separately or replace loosely on jars, as desired. Label and store jars in a cool, dark place. For best quality, use home canned foods within one year.

Notes & Tips